CHARLOTTE, N.C. — The pilot of a US Airways plane may have mishandled a firearm that went off in flight, piercing a hole in the cockpit wall, a federal air marshal and gun safety expert said Tuesday.

"This is an extremely safe and reliable weapon," said Greg Alter, of the Federal Air Marshal Service. "It's not going to discharge on its own is the bottom line."

AP (ENLARGE)

Photos obtained by The Associated Press show a small entry hole in the lower side of the cockpit wall and a small exit hole on the exterior below the cockpit window.

NATION/WORLD National News: LA anti-gang worker gets 12 years for burglary  Research: Giving thanks brings health, happiness  SC lawmakers question impeachment for governor  Feds blame low oxygen for Ala. coal mine death  Obituaries in the news  International News: Icebergs head from Antarctica for New Zealand  Philippines' deadliest massacre tests government  Trial of Khmer Rouge prison chief in final stage  Death toll in China mining blast rises to 106  Comatose for 23 years, Belgian feels reborn  • More Nation/World News • Nation/World Photo Galleries

The pistol -- a .40 caliber semiautomatic H&K USP -- discharged Saturday aboard Flight 1536 from Denver to Charlotte, as the plane with 124 passengers and five crew members was approaching to land. Photos obtained by The Associated Press show a small entry hole in the lower side of the cockpit wall and a small exit hole on the exterior below the cockpit window.

The AP described the photos and the bullet hole to US Airways spokesman Phil Gee, who said "they sound authentic."

Airline officials have said the accidental discharge Saturday did not endanger those on board, although air safety experts said Tuesday the shot could have caused the plane to rapidly depressurize had it hit a window at altitude.

"There are two issues: would they (the crew) have enough oxygen to remain alert," said Earl Dowell, an aeronautical engineering professor at Duke University. "If the crew could no longer control the airplane that would be a big deal. And the rapid loss of pressure might damage the structure itself."

But both Dowell and Fu-Kuo Chang, a professor of aeronautical engineering at Stanford University, said airplane design emphasizes safety and that such a blast -- even if it knocked out a window in mid-flight -- isn't likely to cause the kind of damage that would lead immediately to a crash.

"If not repaired, it may cause a problem. It could get bigger. For a single bullet, it would not be a factor for the safety of the airplane," Chang said. "If it hit the window, it may be a problem for depressurization. I still don't think it would cause a crash."

Dowell pointed to a 1988 Aloha Airlines flight in Hawaii, during which the roof of the jet ripped off after an explosive decompression at 24,000 feet. A flight attendant was blown out of the plane, but the passengers -- many of whom were injured -- remained strapped in their seats and the pilot safey landed the aircraft.

"If they lost a window, the people near that window would have been substantially uncomfortable," Dowell said. "You probably wouldn't have crashed the airplane. But there could have been some frightened people."

The gunshot marked the first time a pilot's weapon has been fired on a plane since the Flight Deck Officer program was created following the Sept. 11 terrorist attacks, Alter said. The Transportation Security Administration is investigating how the gun discharged, and Gee says the unidentified pilot has been taken off duty while that investigation is underway.

Pilots in the program undergo 50 hours of training at the federal Law Enforcement Training Center in Artesia, N.M. Alter said it appears the pilot of the US Airways flight wasn't following "proper procedures. ... We just don't know exactly what procedure wasn't being followed."

Since April 2003, about 5,000 flight deck officers -- captains or first officers -- have gone through the training program and received permission to carry weapons in the cockpit, said Capt. Bob Hesselbein, chairman of the Air Line Pilots Association's National Security Committee. The union represents more than 61,000 pilots at 43 airlines.

Gee declined to say how many US Airways pilots have graudated from the program and carry guns while on duty, citing security.

But they all carry the same gun, the high-priced and high-quality H&K USP, which Alter said was especially selected for the program. Gun safety expert Ronald Scott, a ballistics expert who served for 25 years with the Massachusetts State Police, said the gun wouldn't discharge accidentally if dropped or jarred in someway.

"It's a top-of-the-line model," Scott said. "They're accurate and highly reliable. This is not something that you would just walk into a gun store and buy. And it's also not something that goes off by itself. ... Someone would have to squeeze the trigger."